Calculation of quasi-dimensional flows of boiling liquid
DOI:
https://doi.org/10.7242/1999-6691/2019.12.3.28Keywords:
boiling liquid, quasi-dimensional flows, hyperbolic model, nodal method of characteristicsAbstract
The flow of superheated liquid from a variable-section pipe is studied within the framework of the single-speed two-temperature hyperbolic model of boiling liquid previously proposed by the author. The model is based on the conservation laws for each of mixture fractions and takes into account forces of interfractional interaction. The flow is calculated using a quasi-one-dimensional approximation; liquid fraction is considered to be incompressible. In the calculations, it was assumed that the phase transition occurs under the conditions of a superheated state, when the temperature of the liquid exceeds the saturation temperature, and the intensity of the water - vapor phase transformation is proportional to the superheating of the liquid. A characteristic analysis of the equations of a quasi-one-dimensional fluid flow with phase transformations is carried out and their hyperbolicity is demonstrated. Relations for characteristic directions and differential relations along these characteristics are written. An analytical formula is obtained for calculating the speed of sound in a boiling liquid. It is noted that the speed of sound in a liquid, when phase transitions are taken into account, turns out to be slightly less than Wood's formula gives. The calculation formulas of the iterative algorithm for the node method of characteristics, including the relations at the boundary points, are given. It is shown that taking into account the phase transformation leads to an increase in the concentration of steam, an increase in pressure in the region covered by the rarefaction wave, and the velocity of the mixture at the output section of the pipe increases significantly. In the narrowing sections of the pipe, a decrease in the volume fraction of steam is observed.
Downloads
References
Алексеев М.В., Лежнин С.И., Прибатурин Н.А., Сорокин А.Л. Генерация ударно-волновых и вихревых структур при истечении струи вскипающей воды // Т и А. 2014. Т. 21, № 6. С. 795-798. (English version https://doi.org/10.1134/S0869864314060122">https://doi.org/10.1134/S0869864314060122)
Болотнова Р.Х., Бузина В.А. Пространственное моделирование нестационарной стадии истечения вскипающей жидкости из камер высокого давления // Вычисл. мех. сплош. сред. 2014. Т. 7, № 4. С. 343-352. https://doi.org/10.7242/1999-6691/2014.7.4.33">https://doi.org/10.7242/1999-6691/2014.7.4.33
Суров В.С. Односкоростная модель гетерогенной среды с гиперболичным адиабатическим ядром // ЖВММФ. 2008. Т. 48, № 6. С. 1111-1125. (English version https://doi.org/10.1134/S0965542508060146">https://doi.org/10.1134/S0965542508060146)
Суров В.С. Гиперболическая модель односкоростной теплопроводной смеси с учетом межфракционного теплообмена // ТВТ. 2018. Т. 56, № 6. С. 975-985. https://doi.org/10.31857/S004036440003570-1">https://doi.org/10.31857/s004036440003570-1
Суров В.С. Гиперболическая модель односкоростной вязкой теплопроводной среды // ИФЖ. 2019. Т. 92, № 1. С. 202-214. (English version https://doi.org/10.1007/s10891-019-01922-w">https://doi.org/10.1007/s10891-019-01922-w)
Суров В.С. Гиперболическая модель вскипающей жидкости // Вычисл. мех. сплош. сред. 2019. Т. 12, № 2. С. 185‑191. https://doi.org/10.7242/1999-6691/2019.12.2.16">https://doi.org/10.7242/1999-6691/2019.12.2.16
Feburie V., Giot M., Granger S., Seynhaeve J.M. A model for choked flow through cracks with inlet subcooling // Int. J. Multiphase Flow. 1993. Vol. 19. P. 541-562. https://doi.org/10.1016/0301-9322(93)90087-B">https://doi.org/10.1016/0301-9322(93)90087-B
Downar-Zapolski P., Bilicky Z., Bolle L., Franco J. The non-equilibrium relaxation model for one-dimensional flashing liquid flow // Int. J. Multiphase Flow. 1996. Vol. 22. P. 473-483. https://doi.org/10.1016/0301-9322(95)00078-X">https://doi.org/10.1016/0301-9322(95)00078-x
Pinhasi G.A., Ullmann A., Dayan A. 1D plane numerical model for boiling liquid expanding vapor explosion (BLEVE) // Int. J. Heat Mass Tran. 2007. Vol. 50. P. 4780-4795. https://doi.org/10.1016/j.ijheatmasstransfer.2007.03.016">https://doi.org/10.1016/j.ijheatmasstransfer.2007.03.016
Суров В.С. Об одном варианте метода характеристик для расчета течений односкоростной многокомпонентной смеси // ИФЖ. 2010. Т. 83, № 2. С. 345-350. (English version https://doi.org/10.1007/s10891-010-0353-z">https://doi.org/10.1007/s10891-010-0353-z)
Saurel R., Boivin P., Le Métayer O. A general formulation for cavitating, boiling and evaporating flows // Comput. Fluid. 2016. Vol. 128. P. 53-64. https://doi.org/10.1016/j.compfluid.2016.01.004">https://doi.org/10.1016/j.compfluid.2016.01.004
Нигматулин Р.И., Болотнова Р.Х. Широкодиапазонное уравнение состояния воды и пара. Упрощенная форма // ТВТ. 2011. Т. 49, № 2. С. 310-313. (English version https://doi.org/10.1134/S0018151X11020106">https://doi.org/10.1134/s0018151x11020106)
Уоллис Г. Одномерные двухфазные течения. М: Мир, 1972. 436 c.
###
Alekseev M.V., Lezhnin S.I., Pribaturin N.A., Sorokin A.L. Generation of shockwave and vortex structures at the outflow of a boiling water jet. T and A, 2014, vol. 21, pp. 763-766. https://doi.org/10.1134/S0869864314060122">https://doi.org/10.1134/S0869864314060122
Bolotnova R.Kh., Buzina V.A. Spatial modeling of the nonstationary processes of boiling liquid outflows from high pressure vessels. Vychisl. mekh. splosh. sred – Computational Continuum Mechanics, 2014, vol. 7, no. 4, pp. 343-352. https://doi.org/10.7242/1999-6691/2014.7.4.33">https://doi.org/10.7242/1999-6691/2014.7.4.33
Surov V.S. One-velocity model of a heterogeneous medium with a hyperbolic adiabatic kernel. Comput. Math. and Math. Phys., 2008. vol. 48, pp. 1048-1062. https://doi.org/10.1134/S0965542508060146">https://doi.org/10.1134/S0965542508060146
Surov V.S. Hyperbolic model of a single-speed, heat-conductive mixture with interfractional heat transfer. High Temp., 2018, vol. 56, pp. 890-899. https://doi.org/10.1134/s0018151x1806024x">https://doi.org/10.1134/s0018151x1806024x
Surov V.S. Hyperbolic model of a one-velocity viscous heat-conducting medium. J. Eng. Phys. Thermophy., 2019, vol. 92, pp. 196-207. https://doi.org/10.1007/s10891-019-01922-w">https://doi.org/10.1007/s10891-019-01922-w
Surov V.S. A hyperbolic model of boiling liquid. Vychisl. mekh. splosh. sred – Computational Continuum Mechanics, 2019, vol. 12, no. 2, pp. 185-191. https://doi.org/10.7242/1999-6691/2019.12.2.16">https://doi.org/10.7242/1999-6691/2019.12.2.16
Feburie V., Giot M., Granger S., Seynhaeve J.M. A model for choked flow through cracks with inlet subcooling. Int. J. Multiphase Flow, 1993, vol. 19, pp. 541-562. https://doi.org/10.1016/0301-9322(93)90087-B">https://doi.org/10.1016/0301-9322(93)90087-B
Downar-Zapolski P., Bilicky Z., Bolle L., Franco J. The non-equilibrium relaxation model for one-dimensional flashing liquid flow. Int. J. Multiphase Flow, 1996, vol. 22, pp. 473-483. https://doi.org/10.1016/0301-9322(95)00078-X">https://doi.org/10.1016/0301-9322(95)00078-x
Pinhasi G.A., Ullmann A., Dayan A. 1D plane numerical model for boiling liquid expanding vapor explosion (BLEVE). Int. J. Heat Mass Tran., 2007, vol. 50, pp. 4780-4795. https://doi.org/10.1016/j.ijheatmasstransfer.2007.03.016">https://doi.org/10.1016/j.ijheatmasstransfer.2007.03.016
Surov V.S. On a variant of the method of characteristics for calculating one-velocity flows of a multicomponent mixture. J. Eng. Phys. Thermophy., 2010, vol. 83, pp. 366-372. https://doi.org/10.1007/s10891-010-0353-z">https://doi.org/10.1007/s10891-010-0353-z
Saurel R., Boivin P., Le Métayer O. A general formulation for cavitating, boiling and evaporating flows. Comput. Fluid., 2016, vol. 128, pp. 53-64. https://doi.org/10.1016/j.compfluid.2016.01.004">https://doi.org/10.1016/j.compfluid.2016.01.004
Nigmatulin R.I., Bolotnova R.Kh. Wide-range equation of state of water and steam: Simplified form. High Temp., 2011, vol. 49, pp. 303-306. https://doi.org/10.1134/S0018151X11020106">https://doi.org/10.1134/s0018151x11020106
Wallis G.B. One-dimensional two-phase flow. McGraw-Hill Book Company, 1969. 408 p.
